RMSTATOR New Aftermarket Kit Improved Flywheel + Flywheel Puller + Stator + Voltage Regulator Gasket, RM23048

Brand new, Rmstator Kit Improved Flywheel + Flywheel Puller + Stator + Voltage Regulator Gasket.

PLEASE NOTE: This kit will not fit manual transmissions, but only the automatic models.

Brand new Kit Magneto Flywheel + Puller + Stator + Gasket + Mosfet Voltage Regulator Rectifier

• Direct replacement to your original unit
• Plug-and-play, direct fit, easy installation
• All shipped products are tested

Why our RM11502 flywheel is improved

2002-2007 Suzuki Eiger 400 and 2003-2008 Arctic Cat 400 ATVs are plagued with problems on the original flywheels. The additives in the motor oil were dissolving the epoxy that holds the magnets in the flywheel, causing them to detach and scatter throughout the engine.

The bad news is that by the time the problem occurred, no manufacturer would provide warranty repairs.

EXPOSED EPOXY

DETACHED MAGNET

The good news is that RMSTATOR has manufactured a redesigned flywheel where the magnets are sealed in the flywheel, which reinforces the epoxy and prevents them from detaching. This new flywheel configuration corrects the problem permanently.

Dealership estimates to repair this failure are over $500 in parts alone. RMSTATOR offers you a high quality replacement part that corrects the problem for half the price. The RM11502 flywheel is not only a cost effective way to replace your failed Suzuki or Arctic Cat flywheel, but a great investment when replaced before the failure occurs.

SEAL THAT PROTECTS THE MAGNET’S EPOXY FROM OIL ADDITIVES

• 50 MM x 1.5 Right Hand Female
• Brand new flywheel puller

• Highest grade of lamination materials
• Highest grade of copper winding, resistant to 200 degrees Celsius
• Pick up pulsar coil included
• Connector included
• Rubber grommet included

• Improved heat sink and charging capabilities
• Higher grade of electric components

Stator Dimensions:
Interior diameter: 53 mm
Exterior diameter: 119 mm
Thickness: 15 mm

Other specifications:
Number of wires: 7
Number of plugs: 4
Number of pins: 7

Wire to wire resistance:
Alternator : White Between each White = 0.4 ohms+/-20%
Alternator : White to Ground = O.L. ON DISPLAY
Pick up Coil : Blue to green = 200 ohms+/- 20%
Position Sensor : White to yellow = 0.2 ohms+/- 20%

Voltage Regulator Rectifier Dimensions:
Number of pins : 6
Bracket center to center: 72 mm
Thickness: 28 mm
Height: 84 mm

Minimum Charging Voltage: 14.5 V +/- 0.5 V
Maximum Charging Current: 25 A - 35 A / 300 W - 500 W
Open Circuit Voltage: < 15 V
Operation Temperature: -20? to 85?

Flywheel Dimensions:
Exterior Diameter: 143 mm
Interior Diameter: 120 mm
Interior Diameter Center Housing: 18 mm
Exterior Diameter Center Housing: 42 mm
Thickness (exterior): 12 mm
Thickness (interior): 13 mm

OEM Replaced SKUs

• Sold Each

SKU# RM23048

Fits: